hey guys got a good one for you!
So i was driving my 2008 polaris outlaw 525 irs and it suddenly stopped. got my cuzin to tow me waited 5 minutes it started again for ten seconds then stalled again. Pulled plug no spark to plug, also no spark to wire. Took a test light checked the coil for power and it has no power. Hook the test light end and put it on postive and found that the all 3 wires of the coil are ground(the two grounds and the one signal wire)
Any ideas how to test the magneto, stator, cdi box???
Anybody have a wiring diagram they can send me?
Part in the 60 dollar range. used repair manual/ wiring diagram to diagnose. I'll post a description of how to test it tomorrow if you need me to. I dont think this part is a common failure....
I also had another incident where water got in the cdi box connector. Were you riding through a puddle or crossing stream???