Occasionally while riding our 2002 scrammy 90 seems to bog or act like its running out of fuel then it runs fine again. Any suggestions? usually happens when riding a long straight flat stretch and fuel filter was just changed not long ago.
Occasionally while riding our 2002 scrammy 90 seems to bog or act like its running out of fuel then it runs fine again. Any suggestions? usually happens when riding a long straight flat stretch and fuel filter was just changed not long ago.
Have you taken the carb completely apart and cleaned the jets and passages?
I just did that today, it did not look bad . it only does it occasionally,I probably should have pulled the tank and cleaned the petcock as well but did not think of it until I had re-trailered and garaged it.
Could be some junk floating around in the tank, lines, bowl, etc. Is the spark plug boot tight?
Did not check that .but I will now. Thanks.
You find the problem?Originally posted by ned02
Did not check that .but I will now. Thanks.
Sorry I should have posted the fix. replaced spark plug and made sure boot was tight,I cleaned the carb and we went riding, well it would run for about 2 minutes(about the time it took the filter to fill and then drain the fuel) then act like it was getting no fuel so while everyone else rode I took out the fuel filter and it still did the same thing so I had some extra fuel line and replaced the line from tank to carb and problem was fixed,I think the line had a kink and was restricting the flow.
Great to hear! Thanks for the update.Originally posted by ned02
Sorry I should have posted the fix. replaced spark plug and made sure boot was tight,I cleaned the carb and we went riding, well it would run for about 2 minutes(about the time it took the filter to fill and then drain the fuel) then act like it was getting no fuel so while everyone else rode I took out the fuel filter and it still did the same thing so I had some extra fuel line and replaced the line from tank to carb and problem was fixed,I think the line had a kink and was restricting the flow.
Thanks for the suggestions.
how does your scrambler 90 handle on trails? does it run straight? seems like everytime my daughter is riding hers her quads jumps around the trail alot.. you have that same problem?
2008 Honda 400ex some Mods
2006 KTM 250SXF (pretty much every mod)
2003 KTM 50sx Pro Jr (More modded than my KTM)
2001 Yamaha YZ250 (stock w/ paddle)
2003 Polaris Scrambler 90 (stock)
2005 Weekend Warrior FS2300 (stock)
2002 Sanger V210 Wakeboard Boat (insane stereo)