what is wrong?

[tro_400]

i have a warrior and when it gets onto 3rd gear (or higher) at half throttle.....it sounds like it hits neutral and when it does that it starts making a clicking noise and it wont stop until i come to a complete stop... anyone have any suggestions?

[duke416ex]

Is it still pulling? Does the clutch seem ok in the other gears?

[tro_400]

yes it feels fine in first and second gear but when i hit third it feels like the clutch is slipping or or it drops into neutral

[duke416ex]

Does it do the same in 4th and 5th, Has the bike done anthing strange in a while, like popped loud when going or anything? Sounds like a gear may have gotten broke in the tranny to me, just my opinion. It could be the clutch though, I would think if it is that bad in third though it would slip some in 2nd.

[tro_400]

it does it in 3rd, 4th, 5th, and 6th and it only does it every now and then not all the time

[400exrida]

it sounds to me like u may need to buy a new 4 wheeler it ay be old:)

[2muchquad]

it sounds like it could be your shifter drum.if you have a older warrior,its probably time to replace your forks and the bearings on the drum,and output shaft.if you have 1 and 2nd but nothing else from time to time,i would think its your drum.i would doubt you would have several bent forks.either way you'll have to take it apart to know for sure,good luck:)

[thrasher_ex]

Originally posted by 400exrida
it sounds to me like u may need to buy a new 4 wheeler it ay be old:)


dude.........no......:rolleyes:

[tro_400]

problem is fixed.... just a little oil problem.

[sickmojave]

:huh Do you mind if I ask how the oil caused this problem?

[duke416ex]

probably didn't have any in it and the clutches were getting hot, that'll burn em up!!

[HondaR]

hints for wet clutch...haha..your lucky its still working..im sure you will be rebuilding the clutch soon ..for now ride the $hit out of it